|
02-15-2009, 02:40 PM | #1 |
Fly Emirates :)
Drives: 2010 Yaris Sedan Join Date: Feb 2009
Location: United Arab Emirates
Posts: 69
|
rough surface...
hey ppl, i noticed while washing my yaris sedan... the part of the body below the doors, the lowest part where there is paint. kinda feels rough... i dont think its rough, but the surface is rough. is that normal? just above the ground, below the doors...
|
02-15-2009, 02:54 PM | #2 |
Drives: 08 Yaris Join Date: Oct 2008
Location: Vancouver, BC
Posts: 365
|
normal. all cars are like that
__________________
RIP Yaris, I will miss your superb handling a lot. darkmoon87's picture thread http://www.yarisworld.com/forums/showthread.php?t=10013 |
02-15-2009, 02:57 PM | #3 |
Drives: '08 LB MT Bayou Join Date: Oct 2008
Location: Colorado
Posts: 1,671
|
I think there is some sort of textured finish applied in this area underneath the paint. Probably for weatherizing/rustrpoofing and to prevent all those pebbles and road debris from exposing the metal underneath.
|
02-15-2009, 06:40 PM | #4 |
Is about to 'SeaYa' later
|
Yep, this can be normal. Pretty sure in this case it's where the undercoating and basecoat happen to overlap a little. There are generally two explanations for paint roughness: One is paint sag, which is when the basecoat does not adhere well to the primer, and runs a little before it is cured, leaving little ridges. This is a quality issue with the paint, and would show up over the whole car if it were the case. Two is excessive film build (like when you spray paint and move too slowly). Spray technology has come a long way (most cars only need 2.5-3 gallons to coat now) and things like excess film build can be avoided, even in tough to paint areas, like the door jambs and trunk lips, but since it is a low point, with a sharp angle you may still get some excess build.
|
02-15-2009, 10:00 PM | #5 |
It's a chip guard applied at the factory.
__________________
some people are little slinkies. . . . .they are really good for nothing. . . .but they still bring a smile to your face when you push them down a flight of stairs. Come to the DARKSIDE..... We have candy
|
|
02-16-2009, 07:55 AM | #6 |
Is about to 'SeaYa' later
|
|
02-16-2009, 01:09 PM | #7 |
Fly Emirates :)
Drives: 2010 Yaris Sedan Join Date: Feb 2009
Location: United Arab Emirates
Posts: 69
|
thanks for the reply, u guys :) much appreciated... i have checked on few other yaris as well, they all have it too..
|
Thread Tools | |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Thread Starter | Forum | Replies | Last Post |
Kids have it sorta rough today | GeneW | Off-topic / Other Cars / Everything else Discussions | 5 | 10-19-2008 01:21 AM |
Is the Yaris engine a little rough? | thomasward00 | General Yaris / Vitz Discussion | 23 | 04-30-2007 12:17 PM |
Rough Idle in drive | toyoman | NY / NJ/ CT / PA | 8 | 04-22-2007 03:40 AM |
Rough edges? | jmew0ng | Wash, Wax, Detailing, Exterior Repairs | 2 | 09-14-2006 07:34 PM |