DIY: CHANGE MANUAL TRANNY OIL - Page 7 - Toyota Yaris Forums

YarisPH · 02-17-2013, 12:02 AM

Hi guys! First post here but been lurking for a while. Just wanna say thanks to the one who made this DIY guide! I used 2 quarts of Redline MT-90 on our 2008 Vios (Yaris sedan's name here in the Phils.). Car has 42K ++ kilometers on the ODO. Will observe the gear changes later on, as I've read a lot of good feedbacks on this oil. Many thanks again Yarisworld. :)

hw6515 · 03-28-2013, 01:09 PM

did you try:

http://www.amazon.com/s/ref=nb_sb_no...T-90+GL4+75w90

Be careful with amazon prime.......it's kind of addictive ;)

hw6515 · 03-28-2013, 01:20 PM

Try this link, still prime.

http://www.amazon.com/Red-Line-50504...T-90+GL4+75w90

Hershey · 03-28-2013, 01:58 PM

Go here to possibly find a local dealer , http://www.redlineoil.com/dealers.aspx and here for details http://www.redlineoil.com/product.aspx?pid=46&pcid=7 . Let us know of your purchase and if any improvemnets in performance .

Hershey · 03-29-2013, 12:05 AM

elo179 , you could ask a local private owned auto parts to possibly order it for you . That's what I did . AMSOIL has MTG ( 75w-90 , GL-4 ) synthetic and is usually easier to purchase . MTG , http://www.amsoil.com/shop/by-produc...r-lube-75w-90/ . Good Luck .

regal · 05-17-2013, 10:27 AM

Anyone have a part number for the drain plug washer?

jason214 · 05-17-2013, 07:15 PM

Drain/Filler Plug P/N: 90341-18033
Drain/Filler Plug Gasket P/N: 90430-18008

Hershey · 06-09-2013, 02:16 PM

Well done

. On occasion during an oil change I drop the drain bolt in the oil bucket and have to fish around for it

. Keep us informed on any improvements with the new fill . Well worth the mess .

Hershey · 06-09-2013, 11:57 PM

Can't go wrong at that price . Lady luck must be on your side .

7:34pm · 07-04-2013, 10:19 PM

Sorry but my Yaris is base model and didn't come with an owner's manual.

What type of fluid is recommended for the 5spd manual? Is it 75w90?

thanks

bronsin · 07-05-2013, 06:56 AM

Wilbro how did your engine compartment get so dirty?

I hope you changed the AF too!

Nigel8600 · 10-25-2013, 02:37 AM

I was having the same problem shifting into first (at a very slow speed, maybe 2MPH?) so I found this thread and changed my gear oil to MT90 2 days ago. I cant believe how smooth it shifts now, its like butter........ BUT............. it still grinds when going into first... even when going into 2nd gear just before. Agghhhh

Hershey · 10-26-2013, 12:27 PM

Let us know if the grinding disappears over a period of time .

En4sir · 04-18-2014, 07:09 PM

After purchasing my 2009 3-door hatchback new and putting 165,000 miles on it I decided today (after reading this thread) to change my manual transmission fluid. I followed the advice offered by many here and would like to add a few little tips that I did that should benefit others.

I took some 2-foot long 2" x 8"'s scrap I had laying around and placed a section of 2" x 8" in front of each tire. I then drove the car onto the lumber to increase the ground clearance by another 1.5 inches. It may not sound like much but every bit helps especially when gaining access to the drain plug underneath the car without having to use a jack.

I loosened-up the filler plug just enough to make sure that it could be removed, then removed the drain plug. Draining the transmission fluid without removing the filler plug prevented the transmission fluid from gushing out. After draining about a quart of fluid I then removed the filler plug to allow the transmission to drain completely. No messy spillage anywhere.

I attached a clear vinyl hose 5/8"od / 1/2" id to a small funnel. The hose fit perfectly in the filler hole of the transmission - nice and snug.

Unfortunately I could not find Redline MT90 anywhere locally, so I decided to use Amsoil Severe Gear SAE 75W-90. I referenced the Amsoil website to make sure it could be used in my Yaris.

I test drove the car afterwards and there is a noticable difference in how the transmission shifts - nice and smooth.

Thanks to all the valuable advice posted here in this thread, a job that my local Toyota dealer wanted a $198.95 to do, I did for $25.00 and it took a total of 25 minutes to do.

frambach · 04-20-2014, 01:02 AM

Quote:

Originally Posted by En4sir

I decided to use Amsoil Severe Gear SAE 75W-90. I referenced the Amsoil website to make sure it could be used in my Yaris.

I test drove the car afterwards and there is a noticable difference in how the transmission shifts - nice and smooth.

Thanks to all the valuable advice posted here in this thread, a job that my local Toyota dealer wanted a $198.95 to do, I did for $25.00 and it took a total of 25 minutes to do.

I used Severe Gear as well. I have put 30,000 miles on the lubricant and have been well pleased.

AMSOIL lists Severe Gear as a GL-5 product. Can anyone find (in writing) where Toyota says the Yaris C50 has to have a GL-4? Just curious, I'd like to see it.

When a transmission MUST have a GL-4, AMSOIL makes sure they recommend a GL-4. On the Yaris, the first recommendation is a GL-5.

rningonfumes · 04-20-2014, 08:09 AM

I don't think you'll find anything in writing from the manufacturer that GL-4 is for the Yaris. It's just a general consensus that GL-4 is reviewed by members to feel better for their Yaris. If you search any of the terms ie GL-4 and you'll find that it works better for our synchros among other things.

Here is one particular thread: http://yarisworld.com/forums/showthr...highlight=gl-4

Quote:

Originally Posted by 1stToyota

You probably should have used AMSOIL 75W-90 GL-4 Transaxle Lube...it's what I used and GL-4 is better for the transaxle than the severe gear GL-5, which is meant for differentials.

Nice and succint from this thread:
http://yarisworld.com/forums/showthr...ht=gl-4&page=2

Hershey · 04-20-2014, 01:56 PM

GL-4 is preferred . The AMSOIL Manual Transmission and Transaxles Gear Lube is GL-4 . If it's not giving poor shifting ( grinding , etc. ) you should be fine .

sheekeebut · 06-28-2014, 10:13 AM

Drove my lowered sedan onto 1" thick concrete tiles at the front. Just enough space to floor jack the front up and start working. Thanks OP, you've saved me $200+ in quoted service fees, plus given me some knowledge every Yaris enthusiast should have.

For the record: Motomaster synthetic 75W90, GL-5.

If our manual says says GL-4 OR GL-5, then I shouldn't worry so much about using GL-5. The Toyota engineers would be in deep trouble if they designed a gearbox without considering that they prescribed an oil grade that can harm yellow metals.

07-05-2013, 06:56 AM	#119
bronsin Drives: 2009 Base Hatch 2 Dr Auto Join Date: Dec 2008 Location: nj Posts: 4,783	Wilbro how did your engine compartment get so dirty? I hope you changed the AF too! __________________ Synthetic Oil: Its All In Your Head

10-25-2013, 02:37 AM	#120
Nigel8600 Drives: 2008 Yaris Sedan Join Date: Oct 2013 Location: Calgary AB Posts: 22	I was having the same problem shifting into first (at a very slow speed, maybe 2MPH?) so I found this thread and changed my gear oil to MT90 2 days ago. I cant believe how smooth it shifts now, its like butter........ BUT............. it still grinds when going into first... even when going into 2nd gear just before. Agghhhh __________________

04-18-2014, 07:09 PM	#122
En4sir Drives: '09 Yaris 3dr HB 5sp Join Date: Aug 2009 Location: NE Pennsylvania Posts: 17	After purchasing my 2009 3-door hatchback new and putting 165,000 miles on it I decided today (after reading this thread) to change my manual transmission fluid. I followed the advice offered by many here and would like to add a few little tips that I did that should benefit others. I took some 2-foot long 2" x 8"'s scrap I had laying around and placed a section of 2" x 8" in front of each tire. I then drove the car onto the lumber to increase the ground clearance by another 1.5 inches. It may not sound like much but every bit helps especially when gaining access to the drain plug underneath the car without having to use a jack. I loosened-up the filler plug just enough to make sure that it could be removed, then removed the drain plug. Draining the transmission fluid without removing the filler plug prevented the transmission fluid from gushing out. After draining about a quart of fluid I then removed the filler plug to allow the transmission to drain completely. No messy spillage anywhere. I attached a clear vinyl hose 5/8"od / 1/2" id to a small funnel. The hose fit perfectly in the filler hole of the transmission - nice and snug. Unfortunately I could not find Redline MT90 anywhere locally, so I decided to use Amsoil Severe Gear SAE 75W-90. I referenced the Amsoil website to make sure it could be used in my Yaris. I test drove the car afterwards and there is a noticable difference in how the transmission shifts - nice and smooth. Thanks to all the valuable advice posted here in this thread, a job that my local Toyota dealer wanted a $198.95 to do, I did for $25.00 and it took a total of 25 minutes to do. __________________ "Never argue with an idiot. They drag you down to their level, then beat you with experience."

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Help with oil change specs	autophile	DIY / Maintenance / Service	31	04-25-2011 10:22 PM
Yaris Auto need help with tranny oil change	chrisada_to2a	General Yaris / Vitz Discussion	2	05-17-2007 02:51 PM
DIY Oil Change	Bassmonkey	DIY / Maintenance / Service	42	02-19-2007 09:37 PM
Motor oil debate - interesting info but a long read.	mikeukrainetz	General Yaris / Vitz Discussion	6	12-10-2006 09:16 PM
Oil change question	Ryu	DIY / Maintenance / Service	22	03-08-2006 12:21 AM

02-17-2013, 12:02 AM	#109
YarisPH I've made a post! Drives: 2008 Yaris Sedan Join Date: Feb 2013 Location: Philippines Posts: 1	Hi guys! First post here but been lurking for a while. Just wanna say thanks to the one who made this DIY guide! I used 2 quarts of Redline MT-90 on our 2008 Vios (Yaris sedan's name here in the Phils.). Car has 42K ++ kilometers on the ODO. Will observe the gear changes later on, as I've read a lot of good feedbacks on this oil. Many thanks again Yarisworld. :)

03-28-2013, 01:09 PM	#110
hw6515 Drives: 08 Yaris AT, 350Z GT MT Join Date: Feb 2013 Location: U.S Posts: 70	did you try: http://www.amazon.com/s/ref=nb_sb_no...T-90+GL4+75w90 Be careful with amazon prime.......it's kind of addictive ;)

03-28-2013, 01:20 PM	#111
hw6515 Drives: 08 Yaris AT, 350Z GT MT Join Date: Feb 2013 Location: U.S Posts: 70	Try this link, still prime. http://www.amazon.com/Red-Line-50504...T-90+GL4+75w90

03-28-2013, 01:58 PM	#112
Hershey Drives: 08 Yaris sedan auto / Fit auto Join Date: Oct 2009 Location: northeast Posts: 2,894	Go here to possibly find a local dealer , http://www.redlineoil.com/dealers.aspx and here for details http://www.redlineoil.com/product.aspx?pid=46&pcid=7 . Let us know of your purchase and if any improvemnets in performance .

03-29-2013, 12:05 AM	#113
Hershey Drives: 08 Yaris sedan auto / Fit auto Join Date: Oct 2009 Location: northeast Posts: 2,894	elo179 , you could ask a local private owned auto parts to possibly order it for you . That's what I did . AMSOIL has MTG ( 75w-90 , GL-4 ) synthetic and is usually easier to purchase . MTG , http://www.amsoil.com/shop/by-produc...r-lube-75w-90/ . Good Luck .

05-17-2013, 10:27 AM	#114
regal Drives: 09 Yaris 3 Dr White LB Join Date: Mar 2009 Location: PA Posts: 432	Anyone have a part number for the drain plug washer?

05-17-2013, 07:15 PM	#115
jason214 Drives: 2007 Yaris Hatchback Join Date: Sep 2011 Location: Halifax NS Posts: 11	Drain/Filler Plug P/N: 90341-18033 Drain/Filler Plug Gasket P/N: 90430-18008

06-09-2013, 02:16 PM	#116
Hershey Drives: 08 Yaris sedan auto / Fit auto Join Date: Oct 2009 Location: northeast Posts: 2,894	Well done . On occasion during an oil change I drop the drain bolt in the oil bucket and have to fish around for it . Keep us informed on any improvements with the new fill . Well worth the mess .

06-09-2013, 11:57 PM	#117
Hershey Drives: 08 Yaris sedan auto / Fit auto Join Date: Oct 2009 Location: northeast Posts: 2,894	Can't go wrong at that price . Lady luck must be on your side .

07-04-2013, 10:19 PM	#118
7:34pm Drives: 07 Yaris Join Date: Sep 2012 Location: British Columbia Posts: 132	Sorry but my Yaris is base model and didn't come with an owner's manual. What type of fluid is recommended for the 5spd manual? Is it 75w90? thanks

10-26-2013, 12:27 PM	#121
Hershey Drives: 08 Yaris sedan auto / Fit auto Join Date: Oct 2009 Location: northeast Posts: 2,894	Let us know if the grinding disappears over a period of time .

04-20-2014, 01:56 PM	#125
Hershey Drives: 08 Yaris sedan auto / Fit auto Join Date: Oct 2009 Location: northeast Posts: 2,894	GL-4 is preferred . The AMSOIL Manual Transmission and Transaxles Gear Lube is GL-4 . If it's not giving poor shifting ( grinding , etc. ) you should be fine .

06-28-2014, 10:13 AM	#126
sheekeebut Minimalist Drives: 07 silver sedan Join Date: Jun 2014 Location: Mississauga, GTA, Toronto, ON Posts: 432	Drove my lowered sedan onto 1" thick concrete tiles at the front. Just enough space to floor jack the front up and start working. Thanks OP, you've saved me $200+ in quoted service fees, plus given me some knowledge every Yaris enthusiast should have. For the record: Motomaster synthetic 75W90, GL-5. If our manual says says GL-4 OR GL-5, then I shouldn't worry so much about using GL-5. The Toyota engineers would be in deep trouble if they designed a gearbox without considering that they prescribed an oil grade that can harm yellow metals.